Research progress of CO<sub>2</sub> chemical conversion technology under the dual-carbon target

LI Hanfei; LIU Fang; AN Ning; SUN Zhongqi; CHEN Peng; WANG Fei

doi:10.7513/j.issn.1004-7638.2025.04.014

Volume 46 Issue 4

Aug. 2025

Turn off MathJax

Article Contents

Article Navigation > IRON STEEL VANADIUM TITANIUM > 2025 > 46(4): 103-110

LI Hanfei, LIU Fang, AN Ning, SUN Zhongqi, CHEN Peng, WANG Fei. Research progress of CO2 chemical conversion technology under the dual-carbon target[J]. IRON STEEL VANADIUM TITANIUM, 2025, 46(4): 103-110. doi: 10.7513/j.issn.1004-7638.2025.04.014

Citation:

LI Hanfei, LIU Fang, AN Ning, SUN Zhongqi, CHEN Peng, WANG Fei. Research progress of CO₂ chemical conversion technology under the dual-carbon target[J]. IRON STEEL VANADIUM TITANIUM, 2025, 46(4): 103-110. doi: 10.7513/j.issn.1004-7638.2025.04.014

Citation:

PDF( 1670 KB)

Research progress of CO₂ chemical conversion technology under the dual-carbon target

doi: 10.7513/j.issn.1004-7638.2025.04.014

State Key Laboratory of Metallic Materials for Marine Equipment and Applications, Ansteel Iron & Steel Research Institute, Anshan 114009, Liaoning, China

More Information

Received Date: 2024-09-05
Available Online: 2025-08-31
Publish Date: 2025-08-31

Abstract

Abstract

To address the severe challenges presented by global climate change, China has explicitly proposed the strategic goal of achieving carbon peaking and carbon neutrality. Developing suitable CO₂ utilization technology is the key to achieve the so-called Dual Carbon Goals. Converting CO₂ into valuable products and resources through such technologies not only enables the reduction of carbon emissions but also generates economic benefits. Based on the strategic demands of the Dual Carbon Goals as well as the developmental trends and significance of CO₂ utilization technologies, this review focuses on the research progress in CO₂ chemical conversion technologies in China. It systematically describes the current status of three major technical pathways—photocatalytic, electrocatalytic, and thermocatalytic reduction—while discussing the challenges faced by these technologies and corresponding potential solutions. Finally, recommendations are proposed for the future development of CO₂ chemical conversion technologies in China.
- Dual Carbon Goals,
- CO₂ chemical conversion,
- CO₂ hydrogenation,
- CO₂ catalysis

FullText(HTML)

References(50)

References

[1]	IEA. IEA (2024), CO₂ Emissions in 2023[Z/OL]. https://www.iea.org/reports/co2-emissions-in-2023.
[2]	ZHOU Z X, GAO P. Direct carbon dioxide hydrogenation to produce bulk chemicals and liquid fuels via heterogeneous catalysis[J]. Chinese Journal of Catalysis, 2022, 43(8): 2045-2056. doi: 10.1016/S1872-2067(22)64107-X
[3]	LI C X, ZHANG Y, ZHANG K X, et al. Research on resource utilization of CO₂ in steel industry[J]. Materials Reports, 2023, 37(S2): 468-473. (李晨晓, 张昀, 张凯璇, 等. 钢铁行业中CO₂资源化利用的研究进展[J]. 材料导报, 2023, 37(S2): 468-473. LI C X, ZHANG Y, ZHANG K X, et al. Research on resource utilization of CO₂ in steel industry[J]. Materials Reports, 2023, 37（S2）: 468-473.
[4]	ÁLVAREZ A, BANSODE A, URAKAWA A, et al. Challenges in the greener production of formates/formic acid, methanol, and DME by heterogeneously catalyzed CO₂ hydrogenation processes[J]. Chemical reviews, 2017, 117(14): 9804-9838. doi: 10.1021/acs.chemrev.6b00816
[5]	RODRIGUEZ J A, EVANS J, FERIA L, et al. CO₂ hydrogenation on Au/TiC, Cu/TiC, and Ni/TiC catalysts: Production of CO, methanol, and methane[J]. Journal of catalysis, 2013, 307: 162-169. doi: 10.1016/j.jcat.2013.07.023
[6]	WANG F, HARINDINTWALI J D, YUAN Z Z, et al. Technologies and perspectives for achieving carbon neutrality[J]. The innovation, 2021, 2(4):100180.
[7]	LIU J Y, LI P S, JIA S Q, et al. Electrocatalytic CO₂ hydrogenation to C₂₊ alcohols catalysed by Pr–Cu oxide heterointerfaces[J]. Nature Synthesis, 2025: 1-14.
[8]	ONO S, KANEGA R, KAWANAMI H. Direct formic acid production by CO₂ hydrogenation with Ir complexes in HFIP under supercritical conditions[J]. Organometallics, 2024, 43(19): 2213-2220. doi: 10.1021/acs.organomet.4c00229
[9]	RONDA-LLORET M, ROTHENBERG G, SHIJU N R. A critical look at direct catalytic hydrogenation of carbon dioxide to olefins[J]. ChemSusChem, 2019, 12(17): 3896-3914. doi: 10.1002/cssc.201900915
[10]	ZHAO J B, BIAN F M. Progress on basis and application of CO₂ chemical conversion technologies[J]. Chemical Industry and Engineering Progress, 2022, 41(S1): 524-535. (赵锦波, 卞凤鸣. CO₂化学转化基础与应用研究进展[J]. 化工进展, 2022, 41(S1): 524-535. ZHAO J B, BIAN F M. Progress on basis and application of CO₂ chemical conversion technologies[J]. Chemical Industry and Engineering Progress, 2022, 41（S1）: 524-535.
[11]	NANDAL N, JAIN S L. A review on progress and perspective of molecular catalysis in photoelectrochemical reduction of CO₂[J]. Coordination Chemistry Reviews, 2022, 451: 214271. doi: 10.1016/j.ccr.2021.214271
[12]	WU H, MENG F M. Research progress of modified nano-TiO₂ composite materials in the field of photocatalysis[J]. Material Sciences, 2021, 11: 1003. (吴昊, 孟凡明. 改性纳米TiO₂复合材料在光催化领域研究进展[J]. 材料科学, 2021, 11: 1003. doi: 10.12677/MS.2021.119116 WU H, MENG F M. Research progress of modified nano-TiO₂ composite materials in the field of photocatalysis[J]. Material Sciences, 2021, 11: 1003. doi: 10.12677/MS.2021.119116
[13]	ZHANG X, ZHANG Z Q, SUN Y D, et al. A review on WO₃-based composite photocatalysts: synthesis, catalytic mechanism and diversified applications[J]. Rare Metals, 2024: 1-19.
[14]	QIAN Y, ZHANG F, PANG H. A review of MOFs and their composites-based photocatalysts: synthesis and applications[J]. Advanced Functional Materials, 2021, 31(37): 2104231. doi: 10.1002/adfm.202104231
[15]	ZHAO B B, ZHONG W, CHEN F, et al. High-crystalline g-C₃N₄ photocatalysts: Synthesis, structure modulation, and H₂-evolution application[J]. Chinese Journal of Catalysis, 2023, 52(9): 127. (赵彬彬, 钟威, 陈峰, 等. 高晶化 g-C₃N₄ 光催化剂: 合成, 结构调控和光催化产氢[J]. 催化学报, 2023, 52(9): 127. ZHAO B B, ZHONG W, CHEN F, et al. High-crystalline g-C₃N₄ photocatalysts: Synthesis, structure modulation, and H₂-evolution application[J]. Chinese Journal of Catalysis, 2023, 52（9）: 127.
[16]	NING S, OU H, LI Y, et al. Co⁰- Co^δ+ Interface double-site-mediated C−C coupling for the photothermal conversion of CO₂ into light olefins[J]. Angewandte Chemie International Edition, 2023, 62(23): e202302253. doi: 10.1002/anie.202302253
[17]	DU C Y, SHENG J P, ZHONG F Y, et al. Rational design and mechanistic insights of advanced photocatalysts for CO₂ to C₂₊ production: Status and challenges[J]. Chinese Journal of Catalysis, 2024, 60(5): 25. (杜晨宇, 盛剑平, 钟丰忆, 等. 光催化二氧化碳还原制多碳产物的先进光催化剂设计与机制: 现状与挑战[J]. 催化学报, 2024, 60(5): 25. DU C Y, SHENG J P, ZHONG F Y, et al. Rational design and mechanistic insights of advanced photocatalysts for CO₂ to C₂₊ production: Status and challenges[J]. Chinese Journal of Catalysis, 2024, 60(5): 25.
[18]	YU Y Y, HE Y, YAN P, et al. Boosted C–C coupling with Cu–Ag alloy sub-nanoclusters for CO₂-to-C₂H₄ photosynthesis[J]. Proceedings of the National Academy of Sciences, 2023, 120(44): e2307320120. doi: 10.1073/pnas.2307320120
[19]	WU H L, LI X B, TUNG C H, et al. Semiconductor quantum dots: an emerging candidate for CO₂ photoreduction[J]. Advanced Materials, 2019, 31(36): 1900709. doi: 10.1002/adma.201900709
[20]	GUO Q, LIANG F, LI X B, et al. Efficient and selective CO₂ reduction integrated with organic synthesis by solar energy[J]. Chem, 2019, 5(10): 2605-2616. doi: 10.1016/j.chempr.2019.06.019
[21]	BAI Z M, LIU H H, CHEN K Y, et al. Recent progress on chemical conversion of carbon dioxide[J]. Shandong Chemical Industry, 2018, 47(11): 70-72, 76. (白振敏, 刘慧宏, 陈科宇, 等. 二氧化碳化学转化技术研究进展[J]. 山东化工, 2018, 47(11): 70-72, 76. doi: 10.3969/j.issn.1008-021X.2018.11.030 BAI Z M, LIU H H, CHEN K Y, et al. Recent progress on chemical conversion of carbon dioxide[J]. Shandong Chemical Industry, 2018, 47（11）: 70-72, 76. doi: 10.3969/j.issn.1008-021X.2018.11.030
[22]	KONG X Y, XIE L, WANG Y M, et al. CO₂ capture and resource utilization[J]. Chemical Industry and Engineering Progress, 2022, 41(3): 1187-1198. (孔祥宇, 谢亮, 王延民, 等. CO₂的捕集及资源化利用[J]. 化工进展, 2022, 41(3): 1187-1198. KONG X Y, XIE L, WANG Y M, et al. CO₂ capture and resource utilization[J]. Chemical Industry and Engineering Progress, 2022, 41（3）: 1187-1198.
[23]	QIAO J, LIU Y, HONG F, et al. A review of catalysts for the electroreduction of carbon dioxide to produce low-carbon fuels[J]. Chemical Society Reviews, 2014, 43(2): 631-675. doi: 10.1039/C3CS60323G
[24]	ZHENG Y B, ZHANG Q, SHI J, et al. Research progress of catalysts for electrocatalytic reduction of CO₂ to various products[J]. Chemical Industry and Engineering Progress, 2022, 41(3): 1209-1223. (郑元波, 张前, 石坚, 等. 电催化还原CO₂生成多种产物催化剂研究进展[J]. 化工进展, 2022, 41(3): 1209-1223. ZHENG Y B, ZHANG Q, SHI J, et al. Research progress of catalysts for electrocatalytic reduction of CO₂ to various products[J]. Chemical Industry and Engineering Progress, 2022, 41（3）: 1209-1223.
[25]	SU W L, FAN Y. Progress of electrocatalytic reduction of CO₂ on metal-based materials[J]. Chemical Industry and Engineering Progress, 2021, 40(3): 1384-1394. (苏文礼, 范煜. 金属基材料电催化CO₂还原的研究进展[J]. 化工进展, 2021, 40(3): 1384-1394. SU W L, FAN Y. Progress of electrocatalytic reduction of CO₂ on metal-based materials[J]. Chemical Industry and Engineering Progress, 2021, 40（3）: 1384-1394.
[26]	CHEN H, LI Z H, ZHANG Z H, et al. Synthesis of composition-tunable syngas from efficiently electrochemical conversion of CO₂ over AuCu/CNT bimetallic catalyst[J]. 2019, 58(34): 15425-15431.
[27]	YAN X, CHEN C, WU Y, et al. Efficient electroreduction of CO₂ to C₂₊ products on CeO₂ modified CuO[J]. Chemical science, 2021, 12(19): 6638-6645. doi: 10.1039/D1SC01117K
[28]	CHEN C J, YAN X P, LIU S J, et al. Highly efficient electroreduction of CO₂ to C₂⁺ alcohols on heterogeneous dual active sites[J]. Angewandte Chemie, 2020, 132(38): 16601-16606. doi: 10.1002/ange.202006847
[29]	GUO L S, SUN J, GE Q J, et al. Recent advances in direct catalytic hydrogenation of carbon dioxide to valuable C₂₊ hydrocarbons[J]. Journal of Materials Chemistry A, 2018, 6(46): 23244-23262. doi: 10.1039/C8TA05377D
[30]	JIA J Y, SHAN Y L, TUO Y X, et al. Review of iron-based catalysts for carbon dioxide fischer–tropsch synthesis[J]. transactions of Tianjin University, 2024: 1-20.
[31]	LI J, HE Y L, TAN L, et al. Integrated tuneable synthesis of liquid fuels via Fischer–Tropsch technology[J]. Nature Catalysis, 2018, 1(10): 787-793. doi: 10.1038/s41929-018-0144-z
[32]	ZHENG Y H, XU C H, ZHANG X, et al. Synergistic effect of Alkali Na and K promoter on Fe-Co-Cu-Al catalysts for CO₂ hydrogenation to light hydrocarbons[J]. Catalysts, 2021, 11(6): 735. doi: 10.3390/catal11060735
[33]	YANG S, CHUN H J, LEE S, et al. Comparative study of olefin production from CO and CO₂ using Na-and K-promoted zinc ferrite[J]. ACS Catalysis, 2020, 10(18): 10742-10759. doi: 10.1021/acscatal.0c02429
[34]	NASRIDDINOV K, MIN J E, PARK H G, et al. Effect of Co, Cu, and Zn on FeAlK catalysts in CO₂ hydrogenation to C₅₊ hydrocarbons[J]. Catalysis Science & Technology, 2022, 12(3): 906-915.
[35]	XU Y, ZHAI P, DENG Y C, et al. Highly selective olefin production from CO₂ hydrogenation on iron catalysts: a subtle synergy between manganese and sodium additives[J]. Angewandte Chemie, 2020, 132(48): 21920-21928. doi: 10.1002/ange.202009620
[36]	YANG H Y, DANG Y R, CUI X, et al. Selective synthesis of olefins via CO₂ hydrogenation over transition-metal-doped iron-based catalysts[J]. Applied Catalysis B: Environmental, 2023, 321: 122050. doi: 10.1016/j.apcatb.2022.122050
[37]	TORRES GALVIS H M, DE JONG K P. Catalysts for production of lower olefins from synthesis gas: a review[J]. ACS catalysis, 2013, 3(9): 2130-2149. doi: 10.1021/cs4003436
[38]	MA G Y, XU Y F, WANG J, et al. Research progress of iron-based catalyst for converting syngas directly to light olefins[J]. Chemical Industry and Engineering Progress, 2018, 37(3): 992-1000. (马光远, 徐艳飞, 王捷, 等. 合成气直接法制取低碳烯烃铁基催化体系研究进展[J]. 化工进展, 2018, 37(3): 992-1000. MA G Y, XU Y F, WANG J, et al. Research progress of iron-based catalyst for converting syngas directly to light olefins[J]. Chemical Industry and Engineering Progress, 2018, 37（3）: 992-1000.
[39]	HE X, CHEN D R, WANG W N. Bimetallic metal-organic frameworks (MOFs) synthesized using the spray method for tunable CO₂ adsorption[J]. Chemical Engineering Journal, 2020, 382: 122825. doi: 10.1016/j.cej.2019.122825
[40]	ZENG G T, QIU J, LI Z, et al. CO₂ reduction to methanol on TiO₂-passivated GaP photocatalysts[J]. ACS Catalysis, 2014, 4(10): 3512-3516. doi: 10.1021/cs500697w
[41]	CIMINO S, BOCCIA F, LISI L. Effect of alkali promoters (Li, Na, K) on the performance of Ru/Al₂O₃ catalysts for CO₂ capture and hydrogenation to methane[J]. Journal of CO₂ Utilization, 2020, 37: 195-203. doi: 10.1016/j.jcou.2019.12.010
[42]	WANG Z Q, XU Z N, PENG S Y, et al. High-performance and long-lived Cu/SiO₂ nanocatalyst for CO₂ hydrogenation[J]. ACS Catalysis, 2015, 5(7): 4255-4259. doi: 10.1021/acscatal.5b00682
[43]	WANG S W, WU T J, LIN J, et al. Iron–potassium on single-walled carbon nanotubes as efficient catalyst for CO₂ hydrogenation to heavy olefins[J]. Acs Catalysis, 2020, 10(11): 6389-6401. doi: 10.1021/acscatal.0c00810
[44]	JOHNSON G R, BELL A T. Role of ZrO₂ in promoting the activity and selectivity of Co-based fischer–tropsch synthesis catalysts[J]. ACS Catalysis, 2016, 6(1): 100-114. doi: 10.1021/acscatal.5b02205
[45]	WU T J, LIN J, CHENG Y, et al. Porous graphene-confined Fe–K as highly efficient catalyst for CO₂ direct hydrogenation to light olefins[J]. ACS applied materials & interfaces, 2018, 10(28): 23439-23443.
[46]	XU M J, ZHU M H, CHEN T Y, et al. High value utilization of CO₂: research progress of catalyst for hydrogenation of CO₂ to methanol[J]. Chemical Industry and Engineering Progress, 2021, 40(2): 565-576. (徐敏杰, 朱明辉, 陈天元, 等. CO₂高值化利用: CO₂加氢制甲醇催化剂研究进展[J]. 化工进展, 2021, 40(2): 565-576. XU M J, ZHU M H, CHEN T Y, et al. High value utilization of CO₂: research progress of catalyst for hydrogenation of CO₂ to methanol[J]. Chemical Industry and Engineering Progress, 2021, 40（2）: 565-576.
[47]	SUN K H, ZHANG Z T, SHEN C Y, et al. The feasibility study of the indium oxide supported silver catalyst for selective hydrogenation of CO₂ to methanol[J]. Green Energy & Environment, 2022, 7(4): 807-817.
[48]	WU C Y, LIN L L, LIU J J, et al. Inverse ZrO₂/Cu as a highly efficient methanol synthesis catalyst from CO₂ hydrogenation[J]. Nature communications, 2020, 11(1): 5767. doi: 10.1038/s41467-020-19634-8
[49]	LI M M J, ZENG Z Y, LIAO F L, et al. Enhanced CO₂ hydrogenation to methanol over CuZn nanoalloy in Ga modified Cu/ZnO catalysts[J]. Journal of Catalysis, 2016, 343: 157-167. doi: 10.1016/j.jcat.2016.03.020
[50]	SUN X, LI H. Recent progress of Ga-based liquid metals in catalysis[J]. RSC advances, 2022, 12(38): 24946-24957. doi: 10.1039/D2RA04795K